Water Heater Pop Off Valve Keeps Opening

I will first advise shutting off the cold water supply to the pressure reducing valve once the 12 15 static fill has been established.

Water heater pop off valve keeps opening.

Verify the proper valve is installed the tprv on a water heater is set to discharge at 150 psi or 210 fahrenheit. Your water heater s relief valve can start leaking for one of two reasons. It is a a o smith electric ecs 40 200. First turn off the gas to the water heater or flip the breaker if it s electric.

These numbers will be printed right on the valve or on a tag attached to the. First off i would like you to determine whether the relief valve is popping off due to excessive makeup water or static fill pressure or if the temperature in the boiler is becoming excessive. Both upper and lower thermostats are set to 120 but water temp from the tap is 149 and jumps back and forth to 151 and 149. I did some research and my guess would be that the.

The pressure relief valve on my hot water heater electric keeps popping and sometimes stays open for a long period of time just flowing water. Use a flathead screwdriver to. First you must drain the water heater by attaching a garden hose to the drain valve and then running the other end of the hose to a floor drain or a shower drain. The second reason a water heater relief valve leaks is the water has gotten too hot if the temperature of the water in the water heater reaches above 210 degrees f the relief valve will leak or even blow off this is why the outlet of the relief valve must be piped to about 6 inches from the ground you would not want to get a blast of 210 degree f water in the face.

Close the cold water cut off valve going into the water heater. In the first case the valve will drain water out of the discharge pipe as explained above. Open the valve at the bottom and the pressure relief valve for a minute to drain a little water out of the tank and relieve the pressure. It is easy to isolate your problem to the hott water not the water feed just read the tag that comes on all the tmps they have a preassure rating at witch the will set off your water heater is the only thing that can heat water up to those psi to make it go off.

The unit is 12 yrs old.